Concentrated Disinfecting Teat Dip

Aids in reducing the spread of mastitis-causing organisms

ACTIVE INGREDIENTS:

Glycolic Acid ................... 15%

OTHER INGREDIENTS:

Emollient* ................... 10%

*From glycerin

KEEP OUT OF REACH OF CHILDREN

! DANGER

READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE USING THIS PRODUCT

InstaMixTM Glycolic Concentrate (Part A) is a glycolic concentrate exclusively designed for use in combination with InstaMixTM G Emollient Concentrate (Part B) for on-site blending/production of teat dips.  To be blended with a DeLaval recommended on-site blending unit.

FIRST AID

Immediately call a poison control center or doctor/physician

If in Eyes: Rinse cautiously with water for several minutes.  Remove contact lenses, if present and easy to do.  Continue rinsing.  Immediately call a poison control center or doctor/physician.

If on Skin:  Remove/Take off immediately all contaminated clothing.  Rinse skin with water/shower.  Wash contaminated clothing before reuse.

If Inhaled:  Remove victim to fresh air and keep at rest in a position comfortable for breathing.  Immediately call a poison control center or doctor/physician.

If swallowed:  Rinse mouth.  Do not induce vomiting.

STORAGE AND DISPOSAL

Thoroughly rinse all measuring devices and store out of reach of children.  Avoid contamination of food or feed.  Avoid storing near heat or open flame.  Keep from freezing.  If product is frozen, thaw in warm room and mix well before using. Store in a cool, dry space.  Keep container tightly closed when not in use.  Store locked up.  Do not reuse empty container.  Dispose of contents/container to an approved waste disposal plant.

CHEM-TREC EMERGENCY NUMBER 1-800-424-9300

Not For Human Use

Additional Information on Safety Data Sheet

DIRECTIONS FOR USE

• Do not use full-strength.
• Consult veterinarian before starting or continuing to use teat dip if cow's teats are sore or chapped.
• Do not use teat dip for cleaning and/or sanitizing of dairy equpment.
• Discard any teat sanitizing solution that becomes dirty or contaminated for any reason.
• Good dairy practices suggest the thorough cleaning and sanitizing of teats before milking to avoid contamination and assist in the control of mastitis.
• To mix manually glycolic 3% - 2% (1 part glycolic: 4 parts water), transfer one 55 GAL InstaMix Glycolic Concentrate into an empty 275 GAL tote and fill with water to create a volume to 275 GAL of RTU InstaMix Glycolic 3% - 2% emollient teat dip.  Dilutions with additional emollient must be blended using a DeLaval recommended on-site blending unit.
• To be mixed with InstaMixTM G Emollient Concentrate (Part B) using a DeLaval recommended on-site blending unit.  Can be diluted to create 6 formula options.

USE DIRECTIONS

Pre-Dipping

• Remove excess organic debris and forestrip.
• Dip or spray cow's teats with properly diluted teat dip prepared with a DeLaval recommended on-site blending unit.
• Allow a 30 second contact time.
• Dry teats thoroughly with a clean, single-service paper towel.
• Attach milker unit.

Post-Dipping

• Immediately after removing the milker unit, dip or spray each teat with properly diluted teat dip prepared with a DeLaval recommended on-site blending unit.
• Before exposing cow's teats to below freezing temperatures, the teats should be thoroughly dry to reduce the potential of frostbite.  Failure to follow these instructions may result in frozen teats and injured animals.

UN3265

Corrosive Liquid, Acidic, Organic, N.O.S. (Glycolic Acid)

HAZARD STATEMENTS

Causes severe skin burns and eye damage.  Do not breathe dust/fume/gas/mist/vapors/spray.  Wash face, hands and any exposed skin thoroughly after handling.  Wear protective gloves/protective clothing/eye protection/face protection.

NET CONTENTS:         US GAL. (      L)

LOT NO.:

EXP. DATE:

Add image transcription here...